Chevrolet Cobalt Recalls (2010-2010)
The Chevrolet Cobalt has been the subject of 5 recall campaigns on record with NHTSA across the 2010 model years. They cluster mostly around the air bags, electrical system, and steering.
The Chevrolet Cobalt scores 31 out of 100 (grade D), a busier recall record than most. That score reflects how serious the recalls are rather than how many. 100% involve a critical safety system, none carried a do-not-drive warning, and 0% were issued in the last three years. How the score works.
Those 5 campaigns span 1 model year of the Chevrolet Cobalt. The single largest affected 2,191,014 vehicles, over electrical system. A recall repair is free at a franchised dealer and most never expire, so an older open recall is still worth fixing. Beyond recalls, you can also see the most common Cobalt problems owners report.
The full record is below, grouped first by model year and then listed in detail. Each entry gives the defect NHTSA describes, the safety risk it creates, the manufacturer's remedy, the number of vehicles in that campaign, and the dates. A recall covers a whole production run, so a campaign listed for the Chevrolet Cobalt may not apply to your exact vehicle, and one you have already had repaired will still appear in the history. To see what is actually open and unfixed on a specific car, check its 17-digit VIN.
Chevrolet Cobalt recalls by affected system
Which vehicle systems the recalls touch, using NHTSA's component groups. Select a system to see how it is recalled across every make and model.
Recalls by model year
2010 Chevrolet Cobalt Recalls
5 recalls affect the 2010 Chevrolet Cobalt, involving the air bags, electrical system, and steering.
Every Chevrolet Cobalt recall in detail
Air Bags
- Affected years
- 2010 Chevrolet Cobalt
- Vehicles in this recall
- 59,474
- Reported
- Aug 10, 2015
- Owners notified
- Sep 8, 2015
Defect: General Motors LLC (GM) is recalling certain model year 2010 Chevrolet Cobalt vehicles manufactured January 4, 2010, to June 23, 2010. The affected vehicles may be equipped with an improperly routed Side-Impact Sensor (SIS) wiring harness in the driver side front door. The misrouted wiring harness could cause an electrical short that disables the driver side curtain air bag.
Risk: A disabled driver side roof-rail air bag will not deploy in the event of a crash necessitating deployment of that air bag, increasing the risk of injury to the driver.
Remedy: GM will notify owners, and dealers will inspect the sensor's wiring in the driver's door and make repairs as necessary, free of charge. The recall began on September 8, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15075.
NHTSA campaign number 15V500000.
Electrical System
- Affected years
- 2010 Chevrolet Cobalt
- Vehicles in this recall
- 2,191,014
- Reported
- Apr 10, 2014
- Owners notified
- Apr 18, 2014
Defect: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
NHTSA campaign number 14V171000.
Steering
- Affected years
- 2010 Chevrolet Cobalt
- Vehicles in this recall
- 1,373,177
- Reported
- Mar 31, 2014
- Owners notified
- Jul 17, 2014
Defect: General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Risk: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
NHTSA campaign number 14V153000.
Air Bags
- Affected years
- 2010 Chevrolet Cobalt
- Vehicles in this recall
- 2,190,934
- Reported
- Feb 10, 2014
- Owners notified
- Apr 18, 2014
Defect: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
NHTSA campaign number 14V047000.
Steering
- Affected years
- 2010 Chevrolet Cobalt
- Vehicles in this recall
- 1,050,889
- Reported
- Mar 3, 2010
- Owners notified
- Mar 29, 2010
Defect: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Risk: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
NHTSA campaign number 10V073000.
Common questions about Chevrolet Cobalt recalls
- Does the Chevrolet Cobalt have any recalls?
- Yes. NHTSA has 5 recall campaigns on record for the Chevrolet Cobalt across the 2010 model years. The most common areas are the air bags, electrical system, and steering.
- How many times has the Chevrolet Cobalt been recalled?
- The Chevrolet Cobalt has 5 recall campaigns from the 2010 model years. A single campaign often covers several model years at once, so the number of recalls is not the same as the number of years affected.
- What is the most serious Chevrolet Cobalt recall?
- The most serious recall on record involves the electrical system, affecting 2,191,014 vehicles. If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
- Which Chevrolet Cobalt model year has the most recalls?
- The 2010 Chevrolet Cobalt has the most, with 5 recall campaigns on record. Older model years often pick up more recalls over time, since defects can surface years after a car is built.
- How do I check if my Chevrolet Cobalt has an open recall?
- Enter your 17-digit VIN on the recall check page. It returns the recalls tied to your exact vehicle straight from NHTSA. Recall repairs are free at a franchised dealer, with no expiration on most safety recalls.
Recall data comes from NHTSA's Office of Defects Investigation. For how it is sourced and how the safety score is built, see the methodology and data sources. This page is a reference, not legal or safety advice.